Wilbur-curtis TCC3 Bedienungsanleitung PDF herunterladen

Service Manual, TCC

NSF International requires the following water connection:

1. A quick disconnect or additional coiled tubing (at least 2x the depth of the unit) so that

the machine can be moved for cleaning underneath.

2.Thisequipmentistobeinstalledwithadequatebackowprotectiontocomplywithap-

plicable federal, state and local codes.

3.Waterpipeconnectionsandxturesdirectlyconnectedtoapotablewatersupplyshall

be sized, installed and maintained in accordance with federal, state, and local codes.

Important Safeguards/Symbols

Thisapplianceisdesignedforcommercialuse.Anyservicingotherthancleaningandmaintenance

shouldbeperformedbyanauthorizedWilburCurtisservicecenter.

 •DoNOTimmersetheunitinwateroranyotherliquid

 •Nevercleanwithscouringpowders,bleachorharshchemicals.

Symbols:

WARNINGS – To help avoid personal injury Important Notes/Cautions

Sanitation Requirements

Curtis TCC Units are Factory Pre-Set and Ready to Go… Right out of the Box.

Generallytherewillneverbeareasontochangefactorysettings.However,shouldyouneedto

makeslightadjustmentstomeetyourteaneeds,adjustmentinstructionsareprovidedlaterinthis

manual.

 SystemRequirements:

•WaterSource30–90PSI(MinimumFlowRateof1GPM).Ifincomingwatersupplyisgreater

than90PSI,additionalregulationisrequiredtomeettherange.

•Waterpipeconnectionsandxturesdirectlyconnectedtoapotablewatersupplyshallbe

sized, installed and maintained in accordance with federal, state, and local codes.

SETUP STEPS

Theunitshouldbelevel(lefttorightandfronttoback),locatedonasolidcountertop.Connecta

waterlinefromthewaterltertotheTCCserver.

NOTE:Awaterltrationsystemmustbeusedtohelpmaintaintrouble-freeoperation.Air must

be purged from the cartridge prior to connection to equipment.Inareaswithextremely

hardwater,wehighlyrecommendtheuseofaCurtisapprovedwaterlter.Forourfulllineof

lters,pleaselogontowww.wilburcurtis.com.

INSTALLATION

1.Removedispenserfromcarton.

2.Runawaterlinetotheinletttingbehindthedispenser.Flushthenewwater-

line to remove foreign particles.

3.Connecta¼”aredexibleorcopperwaterlinetothemalettingontheback

of the dispenser.

4.Locatethewatersupplyvalvebehindtheunittoverifypositionisturnedon.

CAUTION:Werecommendthatthewatersupplyvalve,behindunit,beturnedoffduring

non-business hours.

Wilbur Curtis Company, inC.

ModelsIncluded

•TCC1

•TCC2

•TCC3

NOTE:Watersource

pressure must be a

minimumof30PSI

pressure at all times

toinsurethequalityof

the of the product.

5.CleanouttheteaconcentratesystembeforeusingtheTCCserver.UseaBag-in-Boxstyle

cleaningsolutiontosimplifythecleaningprocedure.AcleanerlikeBevCleanbeverageline

cleanercomesina3gallonbag-in-boxthatconnectsdirectlytoyourbag-in-boxsystemforline

cleaning (http://bevclean.com).

 a. Removethequickdisconnectfromtheteaconcentratebag.

 b. PlacetheBIBcleanercontainernexttotheTCCteadispenser.Pullthespoutfromthe 

 cleanerboxthroughthemarkedarea.Removethecleartravelcapfromspout.Don’tworry

about cleaner spilling when the cap is removed. The cap has an internal seal.

c. SnaptheQCDbagconnectorontothebagspout.

OFF

ISO 9001:2008 REGISTERED

WILBUR CURTIS CO., INC.

6913 West Acco Street

Montebello, CA 90640-5403

For the latest information go

to www.wilburcurtis.com

Tel: 800-421-6150

Fax: 323-837-2410

1 2 3 4 5 6 ... 11 12

Inhaltsverzeichnis

Seite 1 - Wilbur Curtis Company, inC

1Service Manual, TCCNSF International requires the following water connection:1. A quick disconnect or additional coiled tubing (at least 2x the depth

Seite 2 - Bag-In-Box

10SYMPTOM POSSIBLECAUSE SOLUTIONTROUBLESHOOTING GUIDEProductowingfromthefaucetistoofoamyorbubbly.1.Reconnecttubingandtightenclamps.2.

Seite 3 - CLEANING

11Page Intentionally Left Blank

Seite 4 - SANITIZING

12Printed in U.S.A. 5/2014 F-3480 Rev SWILBUR CURTIS CO., INC.6913 Acco St., Montebello, CA 90640-5403 USAPhone: 800/421-6150 Fax: 323-837-2410

Seite 5 - DRAWINGS

27. Carefullyliftthebagandsetthebagintothedispenser.8. Resttubingontopofthebag.Routetubingtooppositeproductintakeholeonoo

Seite 6 - ILLUSTRATED PARTS

3MIXING VALVE ADJUSTMENTForcustomerswhowishtoadjusttheavorofthedrink,themixingvalvechangesthewatertoconcentrateratio.Thisvalvei

Seite 7

4CLEANING & SANITIZING (PERFORM DAILY OR AS DIRECTED BY YOUR PRODUCT SUPPLIER)Use a concentrated cleaning solution to simplify the cleaning proced

Seite 8

5ROUGH-IN DRAWINGS

Seite 9

61718192065227811910121315161234ICED COFFEE CONCENTRATE14WATER INLET PARTS BREAKDOWN PAGE 821ILLUSTRATED PARTSTCC1 SHOWN, TCC2 COMPONENTS ARE SIMILAR

Seite 10 - DOs and DON’Ts

75612343018201978910111213151614WATER INLET PARTS ON PAGE 8ILLUSTRATED PARTSTCC3 ALLPARTSAREIDENTICALTOTCC1&TCC2,EXCEPTWHERENOTED1314151

Seite 11 - Page Intentionally Left Blank

8232425272826293*RECOMMENDEDPARTSTOSTOCKILLUSTRATED PARTSPRESSURE REGULATOR & WATER INLET PLUMBING PARTSARECOMMONONALLTCCUNITS2324252627

Seite 12 - Product Warranty Information

9SYMPTOM POSSIBLECAUSE SOLUTIONTROUBLESHOOTING GUIDEDifcultyprimingtheTCCteadispenser.Adjusting rod on mixing valve is turned in too far.Openu

Verwandte Modelle: TCC2 | TCC1 |

Kommentare zu diesen Handbüchern

Keine Kommentare

Wilbur-curtis TCC3 Bedienungsanleitung

Stöbern Sie online oder laden Sie Bedienungsanleitung nach Wasserkocher Wilbur-curtis TCC3 herunter. Wilbur Curtis TCC3 User Manual Benutzerhandbuch

Inhaltsverzeichnis

Verwandte Modelle: TCC2 | TCC1 |

Kommentare zu diesen Handbüchern

Verwandte Produkte und Handbücher für Wasserkocher Wilbur-curtis TCC3